I have built this remote controlled robot to make it possible to "enter" my homepage. You can cruise around the stuff used for experiments described at my pages (e.g. a wind tunnel, a 4-stroke engine and so on). Additionally you can find some other treasure stored at my attic.
Because of the low bandwidth, you have to be patient, because the transmition of a new image needs between 10 and 30 seconds. The control mode is similar to those of a mars rover - try it out!
After an update I have released Rover 2.0.
Now you can alter the camera height and the camera angle so that you also can observe the ground and the ceiling of my robot space.
Another upgrade concerns the camera which has full HD capabilities now (just for the shapshot functionality).
I have attached an infra red interface at the front of the Rover, by which some modules can be actuated.
Cool project and nice done. I drove a little bit around and could see some of your universe by night. And yes i lied when i was asked if I read the manual
Hope I did not wake you up. Saying this…does it make much noice or is your universe sound proofed
I am also trying to connect a robot via internet but got stuck in the chinese only UI of my router to open an incoming port and can’t repace that damn thing since IP TV is running over it too