I need to make a 5 force balance system with 5 s-shaped load cells. Does anyone have any suggestion on which DAQ I can use? Hopefully one that doesnt cost a fortune.
Thanks!
I need to make a 5 force balance system with 5 s-shaped load cells. Does anyone have any suggestion on which DAQ I can use? Hopefully one that doesnt cost a fortune.
Thanks!
Hi @Nonsuch and welcome to our forum.
You could maybe use VINT Hub Phidget and Phidget VINT Wheatstone Bridge Sensor Interface (or Phidgets PhidgetBridge Wheatstone Bridge Sensor Interface (w/ Enclosure)).
See links to these products:
Here is one connection example:
Could this work for you?
That does help!
So can I plug two Wheatstone bridge sensor interface devices into one hub in order to accommodate for five load cells?
What programs would be compatible with this set-up?
Also would I still be able to have separate readings from each sensor?
Thanks!
Hi @Nonsuch
You can find more information here: https://www.phidgets.com/?tier=3&catid=64&pcid=57&prodid=957
Thank you.
Unfortunately, the link provided does not answer my questions.
The only thing I am still not sure about: can I plug in two wheatstone bridge interface into one hub and still get seperate readings for all 5 sensors?
Thanks!
Yes, you should be able to do that.
I didn’t try it personally, but what would be the benefit of the module with more load cells if you cannot read them separately?
Oh, would this setup produce separate readings?
I think it should
I cannot confirm since I didn’t use it…