Good morning,
Can you tell me if the image VFD pin can be mounted directly on the Carbide shapeoko 5 pro at the support without modifications?
Can we send the speed setpoint of the shapeoko to any vfd drive?
I need to 220v vfd kit.
Thanks in advance.
1 Like
Good morning @DarkRc and welcome to our forum.
According to the specs, Shapeoko 5 Pro comes with 65mm router mount and dust boot, so if your VDF spindle kit has this diameter, you shouldn’t have problems mounting it.
Regarding electrical compatibility, I’ve found this topic from Carbide forum which explains similar issue:
In the end, I would suggest you contact Carbide 3D directly so they can help you with all these compatibility questions.
Thank you very much for your answer.
1 Like
You are welcome