Hello
When cutting and soldiering wires together to make them longer i managed to put the VCC from the motor to the Ground of the Driver, which shut down the whole system. To fix this i bought two new HS1 motors, connected them to the same driver, but the software to change ID’s will still not find any servos. Is this because the Driver is also burned?
Hi Aribanani19,
I don’t think connecting the motor polarity reverse would destroy the servos but I would have to test it out myself to be certain.
Connecting the VCC to GND would effectively short the power supply, depending on which supply you use they are usually protected for shorts.
- Have you tried to connect only one servo to your LSS Adapter Board ?
- What’s happening to the servo when you do that ?
Give us as much detail and even upload pictures if you can.
1 Like