I purchased 3 Vyper 120A DC Motor Controllers. They are each to be used on a separate channel with each controlling its own motor. Is there anything special that needs to be done so that they will all function. My past experience has been using multiple ESCs on a single channel and you had to cut the center wire for the slaves to function. Please help as I am getting ready to power up this beast.
1 Like
Hi @BOB_DA_BUILDER !
Here are more info about the product:
http://www.robotpower.com/downloads/Vyper-insert.pdf
http://www.robotpower.com/products/vyper_info.html
According to these, I don’t see anything specific that you should do, especially if your channels and motors are separated.