Hey guy, new to the forum and very new to actuators. I have come up with an idea for a product but am currently stuck. Basically what i am needing to do is tilt a frame from 180 degrees up to 90 degrees using a linear actuator. The frame is hinged with the base frame on one side. the frame will be made out of 1" steel tubing and will be tilting about 60 lbs. What i am stuck on is where to mount the actuator so that the pivot part of the frame can lay flat on the base part of the frame. any input would be greatly appriciated. and like i said i am very new to this stuff so you may have to come down to my level when explaining. Thanks!
Can you including drawing or photo of the setup?