Hi,
I have a SSC-32USB and I am trying to reverse servos on one side using XL and XR commands.
I have tried this using the Sequencer and LynxTerm programs but the commands fail.
Using sliders etc works fine also Demos.
What is the secret?
Are the XL and XR commands supposed to work on the SSC32-USB?
These commands do not work on mine.
Other commands for positioning servos etc work ok.
Sequencer events work ok.
Do you have any suggestions as to why these commands do nothing?
Thanks,
Geoff
Hi Geoff,
You should try the hex sequencer example available in the SSC-32U manual (page 31). It shows an example setup and run:
Hex Sequencer Examples:
"LH1000 LM1400 LL1800 RH2000 RM1600 RL1200 VS3000 <cr>"
Sets the vertical servo parameters.
"LF1700 LR1300 RF1300 RR1700 HT1500 <cr>"
Sets the horizontal servo parameters.
"XL50 XR100 XS100 <cr>"
We tried it on the RB-Lyn-672 over Bluetooth and it worked fine.
Please note that these commands do nothing by themselves. The sequencer always needs a VS command to get started.
Sincerely,