I need to connect “Acxico 1Pcs Joystick Potentiometer JH-D202X-R2/R4 5K 10K ohm 2-axis Sealed PTZ Thermistor” to the motor controller “SmartDriveDou MDDS30”
Could you help me with that please?
This diagram was for the different controllers. I’m going to use two “SmartDriveDou MDDS30” instead. But overall it’s the same set up.
Note that each of the DC motor controllers supplies 5V, and you’ve connected BOTH to your joystick. It’s likely (and best) that you only connect ONE 5V line (you still need common GND and the signal). Check the potentiometer’s rating since each controller assumes 10k resistance (I think, but please check the guides to be sure). The battery wiring seems fine, but something seems to be missing from the key start?
1 Like