Slamware Lidar Robot Map Saving Issue - Error with UWB and Rectangle Area

Hello everyone,

I’m currently facing an issue with my Slamware Lidar Robot when trying to save the map. Every time I attempt to save, I encounter errors related to UWB and the rectangle area. I would greatly appreciate any advice or solutions from those who have experienced similar problems or have expertise with this system.

Details of the Issue:

  • Robot Model: Slamware Lidar Robot
  • Problem: Map saving fails
  • Error Messages: UWB error and rectangle area error

I’ve tried the following troubleshooting steps without success:

  1. Restarting the robot and the mapping process
  2. Ensuring that all connections are secure
  3. Verifying that the environment is properly mapped without obstructions

Has anyone encountered these specific errors before? If so, what steps did you take to resolve them? Are there any settings or configurations that I might be overlooking? Any insights or guidance would be immensely helpful.

Thank you in advance for your support!

Best regards,
Umair Mushtaq

1 Like

Hello @umairmushtaq109 and welcome to our forum!

It seems that none of our members have seen this issue before, since no one replied to this topci.

Was this robot bought from RobotShop?

Did you try contacting Slamtec directly for support?

Thank you.