hey guys , i was working on a project including a XQ-S5040D servo motor , it stopped working properly and chattering and jittring and even when i use a specific location it doesn’t reach the angle properly, what could be the problem ?
Hi,
]How are you powering the servo ? What is your power supply’s voltage and how much current it can provide ?/:m]
]What is the controller you use to control the servo ? (Arduino, servo controller, RC receiver …)/:m]
]Did make sure that the servo’s gears are not stripped and freely rotate ?/:m]We unfortunately don’t offer this servo, therefore, we don’t have much information we can provide.
Contacting directly the manufacturer would be you best option. You can contact them through this email : [email protected]