I noticed in the SCC-32 manual it mentioned that the SCC-32 may reset, and this is indicated by the status light turning on and staying on. What causes the SCC-32 to reset, aside from turning it off? Is there a command that can be sent to reset it?
Powering the VL input from the VS input and moving many servos at once can reset the SSC-32 if the battery current is not enopugh to keep the voltage above 5.5vdc on the VL input. There should be no need to reset the board, so there is no reset command.
Ok, it must be my power supply setup then.
Thank you.