I have a track based project with two jazzy wheelchair motors. I originally had the sabertooth 2x32 but it would over heat after a few minutes of use. so I upgraded to the 2x60 It will work fine some times for a few seconds and then it just goes berzerk! I’m using a Flysky FS-i6 rc controller. my switches are set 1 off and 5 off. batteries are fully charged. Connections look good and clean. Anybody had this problem before? I know almost nothing about computers or robotics.
Hi there,
Welcome to the community.
The first thing you would have to verify is the current drawn by your motors.
Let me know so we can verify if the driver is strong enough to drive the motor.