If you are the original author, please access your User Control Panel and update it.
Hey,This is a project I did over the summer. I made a robotic arm that is contolled with a 1:1 controller. The robotic arm is basically 4 standard servos and three micro servos. All the mounting parts and turn-table is from lynxmotion. The other parts are made from cut pieces of polycarbonate and PVC angles. The microcontroller is an Arduino. I used the Ardweeny from Solarbotics. There is some electrical and duct tape on it since the cut polycarbonate has sharp edges.The controller is made of PVC ...
This is a companion discussion topic for the original entry at https://community.robotshop.com/index.php/robots/show/remote-controlled-robotic-arm