I have lynx 5 robotic arm.I have GP2D12 SENSOR.Where to fit it in LYNX 5 ROBOTIC ARM.HOW TO GIVE CONNECTION TO SSC-32?Please REPLY Sir.
The GP2D12 has three wires. Black is ground, red is 5vdc and the yellow is the analog voltage. The SSC-32 has 4 analog inputs. Right next to these inputs are pins labeled (-) and (+). Connect the black wire to the (-), the red wire to the (+) and the yellow wire to the analog input. You will need to remove the female pins from the black plastic part and put some heat shrink on them. This will protect the pins from shorting out when you install them onto the pins.
I have the 4 analog inputs on my ssc-32 board labeled “A”,“B”,“C”,“D” but they have only two pins how would i connect it?