Hello can you be kind enough to help me solve my problem I built a rc lawnmower and it is working great until I notice when I take my finger off the control stick I notice the lawnmower moving slowly, it look like it still getting signal to move from the receiver. I am using a DXE Controller AR610 receiver and a sarbetooth 2x25 with 2 wheelchair motor all so using a battleswitch to send current to a 30amp automotive realy which turns on a third motor that spins the cylinder or reel and a peico switch that runs the fog light . I disconnect the battleswitch and PicoSwitch from the receiver but that didn’t change anything can someone please help me Thank you Roy.
Like you said, if the motor is still rotating, it seems likely that the controller is receiving a signal. Check your radio to see if it has trim (the little switches below and to the side of the joysticks) and adjust accordingly.
Thank you I will try to make adjustment.
Thank you adjusting the trim and it working fine