Hi!
I require your help regarding a problem I’m encountering.
I’ve written a new program in RoboForth. When I try to download it to the R12 controller, I get an ST Robot error that says “> expected”. And that is it! No numbers, no clue where to look it up at, etc.
Any suggestions?
Need this program for a demo my my local library tonight (16 Oct). This problem just popped up today.
Thanks.
Lynn
Hardware concerned:
ST Robotics R12 robotic arm
Software concerned:
Robwin7
Troubleshooting steps already taken:
Tried reloading a program written earlier that ran just fine. The same error occurs.
Additional information:
Thank you so much in advance for your help!