Hi people!!
Somebody can help to resolve a problem with my arduino one r3, I have the rover shield v1… Already upload the example code include on pdf instructions but still the motor or servo havnt any change.
Idk what else to do!
@Haru30 Welcome to the RobotShop Community. To confirm, you have a DFRobotShop Rover V2?
- Confirm that the gearbox was assembled correctly, the driving sprockets can rotate and the tracks are not under considerable tension
- Confirm the wires are connected between each motor and each terminal
- Confirm the On/Off switch is turned ON and there are batteries connected correctly
- Ensure the batteries are charged
If these don’t resolve the issue, please provide a few clear photos of your setup from the top, sides and bottom.