hello everyone
i have mg995 servo and usbssc32 controller
i want program servos by matlab
mg955 range must be 180 degree
but its just move from 800 to 2200 (about 126 degree)
what can i do?!
i test it with lynxterm too,but same …
tnx
Can you send a signal of 500 to 2500, or is 800 to 2200 really the limit?
If that’s the limit, and sending a signal between 500 to 800 or 2200 to 2500 does not change the position and only causes the servo to vibrate, then its motion is restricted.
Try removing the servo horn and carefully testing the range of motion.
there isnt any vibrate or move when i sending a singnal between 500 to 800 or 2200 to 2500!
i dont know how to remove servo horn!!
Not all servos are created equal. The MG955 might not have the internal software to handle those signals.
If you sent a signal and it don’t react, it can’t handle it.
Whenever I get a servo motor, I test and write down three values.
Idle pulse, full speed fwd, full speed reverse.