Picaxe project board

Hi,

First of all, sorry if this is in the wrong forum. But onto the question:

I've recently been designing my first robot, following the "start here" tutorial. I have most of it designed and drawn up in SketchUp, but the last thing I need to place is the project board (AXE020 for 28X1.) I have the dimensions of the board, but the one thing I would like to find out is whether or not there are any holes to screw the board down with, and if so where they are located (specific measurements if possible) and the diameter of the holes.

Thanks in advance.

A quick search here found
A quick search here found this link, showing a hole on the upper right corner, and mid left. No apparent dimensions, but can estimate from 0.1" spaced pins.

Thanks for the link. Based

Thanks for the link.

Based on the dimensions I had of the board I was able to scale the image down to find the exact measurements.

Thanks for your help

board

i think the board is 60 x 50 mm.

EDIT: Never mind. I just read your post properly. (Banging head on keyboard)

I’ll measure the location of the holes this evening and post them.