Which connector is best suitable for connecting RS-1270 servo to PCB compatible with the connector of the motor? I think bergstrip is a good option but it provide support for only 1A (and 3A according to few manufacturers) while motor have 5A stall rating
I want a right angle connector.
The connector on the RoBoard RS-1270 servo is a standard 0.1" 3-pin connector. Consider a normal 90 degree pin header:
robotshop.com/ca/en/sfe-righ … aders.html
Dear CBenson,
The current rating of this header is not specified. Most of the other manufacturers claim that such headers have current rating of 1A (amazon.com/FCI-Headers-Wire- … B00LWTB8SG).
Rs-1270 have stall current rating of 5A. If such headers are used, they might cause problems.
We certainly see what you mean. However, 5A should not be continuous but rather a “burst” current.
Given that the headers are 0.1" standard, there really is not much choice.
We have not heard of any issues from other customers about current or overheating issues for this line of servos.
Dear CBenson,
Thank you very much for the clarification.