Hi innerbreed,
I am currently working on a 6 Degree of Freedom table that is using 6 hydraulic actuators for its movement. The model can be found here: mts.com/ucm/groups/public/d … 002093.pdf . I noticed that you seem to be an enthusiast of Stewart Platforms/hexapods, so i was wondering if i could ask you a few questions about my design process?
I read that the actuators are a small (but important) part of the design. What are some of the key factors to consider, if actuators are considered a ‘small’ part of the design?
Thanks and looking forward to hear from you!