My First BatchPCB, er batch

So I finally got my first home designed PCBs back from BatchPCB. As a bonus, I got double the parts I ordered.

IMG_2064.jpg

My L298 Motor shield:

IMG_2065.jpg

My Q1114 sensor board (for line following/wheel encoders) The mounting holes will need some rework.

IMG_2066.jpg

My attiny headers (based on http://tinkerlog.com/2009/01/18/attiny-breadboard-headers/) The 20 pin header is a little too narrow. Need to tweak the border.

IMG_2067.jpg

 

I need to get some parts for the motor shield (the screw terminals I have don't match thepart I used in Eagle) so that one will be a couple of days before I play with it. As for the others. Time to get soldering.

 

 

Awesome work, I’ll have to

Awesome work, I’ll have to finish the boards so I can get mine in already.

Out of curiousity, how much was it for you to get these boards, $50 ish??

Ya know, I found that tinkerlog site as well, I based my design losely off of it for my picaxe setup…really excited about that one. :smiley:

That’s about right
It was something like $51/$52.

Great job with the boards. I
Great job with the boards. I tried my first schematic with BatchPCB, but it took 4 weeks before I got my PCB. How long did it take for you to recieve yours?

Thanks
I think it was around 3 1/2 weeks before I got my order.