I just bought a RoBoard RS-1270 high Torque servo for evaluation purposes. I’d like to use it to control a lifter arm one a one lb flipper robot, but I’m not sure how this servo is intended to be mounted. The output side has six small holes (four of which are co-axial with the assembly screw holes in the back). Am I suppose to be small self tapping screws in those holes? That does not seem like a very good plan.
Also note to robotshop.com I bought this servo because your description implies the whole case is aluminum when in fact only the mid section is aluminum. Please update your description to clarify this.
Chris O
ohiorobotclub.com/