Hi guys,
I’m having a problem.
I have a sibertooth 2x32 controller that I’m concocting to him 2 200 watts motors.
The System running on 24 volts and operated by analog joystick.
The thing is that the motors are running weak and slow then I expected.
When I’m checking the output from the controller to the motors with DVM,
the current is 12 volts instead of 24 volts.
I checked the parameters with the software, and everything looks ok…
But maybe I need to change something that I don’t think about.
The joystick is using 2.5 volts in the center, and go up to 5 volts when I push it to the max,
and to 0 when in the opposite direction (I don’t know if it’s ok or not… I thought it should give 5 volts in every direction)
I will most appreciate if you can help me figure it out.
Arik