We purchased 2 XYZ cables from you last month but when we opened up our Makerbot 2 to install we saw that they were the end stop version. We were going to return our cables for these but also noticed that the end stop cables in the printer had 2 of the white motherboard connectors while the photo of your end stop cable only shows one. Please clarify.
Hi Phil,
As specified on the product page, the XYZ Motor cable require the use of the X Motor Jumper Cable to get a finish wiring harness.
This allow the user to, later on, replace only the X Motor cable when it fail.
We hope that help,