WinGUI Serial Connection
Open the WinGUI application and use the Top-Left options to connect your Quadrino Nano. Speed should be set at 115200 by default, but if it's not, you can change it manually. The COM port to use can be different from our example and must match the Windows COM port of your Quadrino Nano.
Note: You need to connect the Quadrino Nano before opening the WinGUI application otherwise there will be no COM port available.
WinGUI MAG Calibration
To initiate the calibration, click on the "Calibrate ACC" button in the "Flight Deck" tab of the WinGUI application. This time you do not have to care about the Quadrino Nano / Copter being level.
WinGUI MAG Calibration Confirmation
WinGUI will ask you to confirm the procedure and steps to take for the calibration. Now click on the "Calibrate ACC" button
Note: The Status (Orange & Green) LED's are flashing while in calibration made.
MAG Calibration - Full 360deg on all Axis
Once you started the MAG calibration, you have to turn your Quadrino Nano / Copter a full 360deg on each axis. While your doing this, the controller will look and calibrate based on the information seen.
Note: The Status (Orange & Green) LED's are flashing while the calibration made.
This is a companion discussion topic for the original entry at https://community.robotshop.com/index.php/blog/show/lynxmotion-quadrino-nano-sensor-calibration