Litter-Robot 3 – Flashing yellow Light and Stuck Mid-Cycle + show blue - yellow - red lights

Help & Support Domestic Robots
1

Hi everyone,

I’m experiencing an issue with my Litter-Robot 3, and I’d really appreciate any help or advice.

The yellow light is flashing, and the unit starts rotating but gets stuck every couple of seconds. Sometimes it doesn’t complete the full rotation to dump the waste properly. In other cases, once the cycle finishes, the light turns red - or cycles through the colors blue - yellow - red.

Any insights or suggestions would be greatly appreciated.

Thanks in advance!

3

You can check this troubleshooting guide Litter-Robot 3: Cat Sensor Troubleshooting Overview until robotshop officials reply you.

1 Like
4

Hello @Jylita

Welcome to the RobotShop Community.

To help us analyze your robot efficiently, could you please let us know if the yellow light is blinking slowly (once per second) or rapidly (twice per second)? Also, could you tell us whether you are using the original power supply cable for the Litter-Robot or a third-party cable?

We look forward to your reply.

Best regards,

1 Like
5

Sure @MNPistagnesi -

  1. Currently, it’s showing blue-yellow-red lights one after the other. When it’s stuck in the middle, it’s showing a yellow light twice per second.
  2. Yes, original power supply.

Thanks!

1 Like
6

Hello @Jylita

To resolve this issue, please follow these steps: Litter-Robot 3: All three lights flashing (Globe position fault)

If none of the above steps resolves the issue, please send us photos of the 3 sets of contact pins. 2 are located on the base and 1 is on the side of the bonnet. (See photo)

Awaiting your response,

Best regards,

1 Like