I tried various solutions mentioned above, but still can’t solve it.
I want to know the test program I use is rightcode.txt (475 Bytes) ?
I also test the Lidarlite input voltage is 4.53V. Is it ok, right ?
Yes, that is the manufacturer’s sample code.
You could try changing it to a different configuration:
Selects one of several preset configurations.
Parameters
----------------------------------------------------------------------------
configuration: Default 0.
0: Default mode, balanced performance.
1: Short range, high speed. Uses 0x1d maximum acquisition count.
2: Default range, higher speed short range. Turns on quick termination
detection for faster measurements at short range (with decreased
accuracy)
3: Maximum range. Uses 0xff maximum acquisition count.
4: High sensitivity detection. Overrides default valid measurement detection
algorithm, and uses a threshold value for high sensitivity and noise.
5: Low sensitivity detection. Overrides default valid measurement detection
algorithm, and uses a threshold value for low sensitivity and noise.
lidarliteAddress: Default 0x62. Fill in new address here if changed. See
operating manual for instructions.
I also test the Lidarlite input voltage is 4.53V. Is it ok, right ?
Yes, that is ok.