Hi
my LR3’s 3 lights flash sequence, and it seems to be stuck by something when the cycle process.
I clean and reassemble the machine several times, It’s also not working. how can i solve this issue?
thanks for your help
best regards
abel
Hi
my LR3’s 3 lights flash sequence, and it seems to be stuck by something when the cycle process.
I clean and reassemble the machine several times, It’s also not working. how can i solve this issue?
thanks for your help
best regards
abel
Hi @tinyeyes
If the Open Air unit cannot find Dump and/or Home position, the control panel will display 3 lights blinking. If you have recently disassembled your globe please advise.
Please remove the globe and check the black gear connected to the motor. When you press on the black gear with your finger, does it seem loose or free‐spinning? If so, please follow the instructions for tightening the set screw, here:
When replacing the globe onto the base, make certain that the track around the outside of the globe is properly aligned into the groove on the base.
If the unit is plugged into a power strip, try plugging it directly into a wall. Sometimes the issue is caused by a fluctuating power supply, low voltage, or other power issues. If the globe is filled past the fill line remove litter so the fill line is exposed.
Can we ask the specifications on the adapter for the power supply you are using Correct Spec: 15VDC regulated adapter 400mA to 1,000mA.
[Note: If you are using a power supply with different specifications, the Litter‐Robot may appear to work properly; however, inadequate power can cause the unit to malfunction over time.]
If the Litter‐Robot does return Home with a solid blue light, there are no issues with the functionality of the unit at this time.