I’m setting up an assembly using a Nema 17 motor -> shaft through a wheel - > bearing support. The wheel will be in the center and will be pressing up against a stack of cards. I’d like to be able to tweak the vertical placement of the entire assembly to put the correct amount of pressure on the cards. I see motor mounts everywhere that allow for horizontal adjustments via slots, but none that allow for vertical adjustment. I’m sure something exists or maybe some other sort of rail/track that I could use. Any suggestions??
Forgot to mention that I’m planning on mounting the assembly to a wooden box and the shaft assembly should be able to move up and down as needed along the sides of the box.
Can you provide a sketch of the setup so we better visualize the adjustment? For example if you want a bearing support moved up and down, you can add washers / shims. Alternatively, use lead screws and nuts to get the right height.