Hi everyone, I need to convert an AL5A base from 180 degree to a full round using gears and I envision to use a 2:1 gear pair. As I’m new to gears, is there anywhere I can get gears which can fit the size or intructions on installation? I show my goal in the picture attached. Thanks!!
The base is set up specifically for a standard sized servo such as the 422HB, and it’s a direct connect to the top moving plate. You might consider replacing the base entirely with a 785HB servo and Add-on Base Rotate:
lynxmotion.com/p-622-add-on- … ervos.aspx
The 785HB can rotate 1260 degrees. You would need a way to mount this base so it was well supported.
robotshop.com/hitec-hs785hb-servo-motor.html
To the original poster: did you find something that worked for you?