How to make wireless Wii sensor bar

Your wii sensor bar's wires are too short?
It takes too much room?

No problem! You can make wireless wii sensor bar instead thinking!

IMG_0173.jpg

So what you need:

Battery holder for one AA-battery
IR-led
Slide switch
Some wire



So carefully now, left side is positive and right negative.
Tape the led on top of the battery holder.
Connect positive power to led's anode.
Now tape the switch to back of the battery holder.
Connect the left pin of the switch to led's cathode.
Then you connect negative power to middle pin of the switch.
Then check with your camera that it works.

And it's ready!

IMG_0175.jpg

Whole thing mounted to top of my tv.

 

Thanks from your attention! 

this is awesome!

this is awesome!

hellowhat is IR-led?it is

hello

what is IR-led?

it is LED diode?

plz reply me 

Infra Red - Light Emitting
Infra Red - Light Emitting Diode

How does wii work?

So that bar is just a fix point for the controller to focus on? The controller is what sends the signal back to the wii, not the controller to the bat then to the wii?.

Doesn’t the Wii require two

Doesn’t the Wii require two IR-LEDs?

 

I would think so. Here’s an

I would think so. Here’s an article that explains what the sensor bar really does, and some ways to replace it.

One thing in the article is that not every Wii game uses the sensor bar. Some rely solely on the accelerometer.