Good Morning,
I’m new to the forum so I catch the opportunity to greet all the community.
I’m designing a very small f1 car robot so I have to challenge the space I have. I want to use this brushed motor robotshop.com/en/solarbotics … -rpm2.html and I’m struggling to engineer the transmission to the rear wheels. 3D printing the space for gears is the last option, have you any idea (suggesting also products) of how I should act?
I was thinking about a pulley and stripe system even though a fast ratio gearbox would be better.
Hoping in your suggestions.
Thanks in advance.
Best regards
Giacomo
A small set of spur gears would be best. Unfortunately we do not have any that small.
Could you suggest any solution for a small but with high-rpm propulsion for the wheels?
For example other micro motors.
We do not carry any as small as that motor. A brushless DC motor would be nice but those we carry are all significantly larger.
robotshop.com/en/bldc-motors.html
Ok, thank you anyway