Here is my first creation.
List of Merchants:
https://www.pololu.com/
http://www.dfrobot.com/
Action Graphics
http://www.sparkfun.com/ List of parts Mecanum wheels - 4 pack Romeo-All in one Controller (Arduino Compatible Atmega 328) 2A Dual Motor Controller Sharp GP2D12 Mounting Bracket Sharp GP2Y0A21 Distance Sensor (10-80cm) Pan and Tilt Kit (Black Anodized) (no servos) Hitec HS422 Servo x2 Tamiya 70097 Twin-Motor Gearbox Kit x2 Tamiya 70098 Universal Plate Set x2 Tamiya 70105 3mm Diameter Shaft Set x2 Rechargeable NiMH Battery Pack: 8.4 V, 2200 mAh, 4+3 AA Cells, JR Connector x2 Standoffs and screws were purchased at Pololu Eddie is built using the DFR's Romeo and their 2 Amp Motor driver breakout board. The Chasis was designed on Corel Draw and cut out by Action Graphics. Action Graphics is a local company that does laser etching engraving and cutouts. If anyone needs a chasis cutout out let me know. We are working on the sketch now to get him up and running. Wish us Luck!
This is a companion discussion topic for the original entry at https://community.robotshop.com/robots/show/edwardo-v2-0