Drawings and dimensions for the base rotate turntable

Are there dimensions online for the base rotate turntable? Like hole spacing on the top, mounting, etc.?
Thanks.

The overall dims are on the website.

Top diameter = 3.688"
Bottom diameter = 3.875"
Height = 1.875"

The holes on the top are the SES hole pattern.

4 x 0.094" holes on a 0.656" circle.

I’ve heard some complaints in the hallway about this base stuttering due to giving to much friction on the 4 balls supporting it.

Should it be greaced?

There’s 5 balls not 4. If it’s assembled correctly it will not stutter. This includes sanding the imperfections from the bearings as instructed in the assembly guide. The instructions also tell you to oil the bearings. How does one “give too much friction?” Read the forums. There is not one single post complaining about the base. I invite the hallway complainers to post here. I will help them follow the instructions.

Ahh i shall inform them, thanks!

If possible i would striketru & rectify my previous post.