Careful with tools, kids

So I guess this is as good as time as any to post my first blog post.

 

A warning on the dangers of robotery.

Don't get so into your work that you forget about safety.

I was shaving off some plastic from a wheel to use it as a homemade pulley for moving a motor for Mr. Tea, when the exacto knife slipped and sliced into my finger.

I didn't think it was too bad until blood came gushing out, turning my sink a lovely shade.

My husband was yelling at me to not move my finger while I flexed it, checking to make sure I didn't sever any tendons.

 

Luckily, I didn't make it that far, but my husband is now watching over my shoulder while I work to make sure I play it safe.

No more fun stuff *sigh*

The blood hides it, I couldn't take the towel off of it fast enough to get a clear picture.

100_0342.jpg

Play it safe everyone!

did a similar thing as you,
did a similar thing as you, TheCowGod, cut the top bit of my lft thum dow the middle, after it stopped bleeding i could pull the bit with the finger print from the bit with the nail. it took loads of time to heel, didnt event get stiches…

the point is anything that cuts or melts stuff is realy dangerous !!!