Cad and Drawings

Let's Make Robots Project Ideas
1

Hi,

I have a project in which I need a Passive (no motor action) Revolute (pin) Joint to attach two Rods.
I also have to read the angle in this joint (through an encoder).

I was think about use 2 Servo Brackets like those:
robotshop.com/ca/lynxmotion-c-large-servo-bracket-two-pack-asb-205.html

The problem is that I couldn’t find the draws, sizes and dimensions of those brackets. Is there any place I could find the draws? Or 3D Cad version of those components?

Thanks.

2

Unfortunately ServoCity does not make their CAD files public.

3

The CAD files we currently have available for Lynxmotion parts can be found here:
lynxmotion.com/s-5-ses-3d-models.aspx

4

The CAD drawing for that part can be found here (SolidWorks 2011).

5

That is very useful Cbenson, thank you!

However, there are some parts that I’m interested which are manufactured by SERVOCITY. Would you have a link for their CAD FILES too?

Thank you very much again!

6

All right,
thank you anyway.

7