Any Blackbird 2 3D camera users left out there? I just received one to replace a camera on my FPV rig, in case on a crawler. I also have many quads with cams so familiar with the technology.
Hookup is via the ribbon cable: pin 9 to vid, 7 to gnd (hooked to Rx), 6 to pwr, and 5 to gnd (connected to JST for battery.
The screen remains black, but I can see the OSD in my groundstation Rx, a Clearview Pro 5.8; static screen as I switch channels or protocol.
Video Tx is a ReadymadeRC Cricket 600, goggles are ZEISS Cinemizer, which seem to detect a 3D signal when I look at in-screen settings; defaults to 3D side-by-side.
Update: Located firmware and ran Blackbird 2 Assistant. Update was successful. Serial number not showing in Assistant screen (as mentioned in instructions)
Any assistance would be greatly appreciated,
Dave