I am new to the RobotShop forum. I have the beginner level Robotis Bioloid kit. I am using the new RoboPlus software because the software supplied with the robot would not see my Dynamixel servos. I updated the firmware for the CM-5 as instructed by Robotis and can now recognize all the servos while running the check. When I run “check assembly” program in Behavior Program I get the following:
{[CM-5:1.1963]} {[PC:57142(BPS)][DXL:1000000(BPS)]} { 001:012(AX012] 002:012(AX012] 003:012(AX012] 004:012(AX012] }
{[DXL:005(PCS)]}
When I run the Demo Example(Walking Droid):
{[CM-5:1.1963]} {[PC:57142(BPS)][DXL:1000000(BPS)]} { 001:012(AX012] 002:012(AX012] 003:012(AX012] 004:012(AX012] } {[DXL:005(PCS)]}
{[ME]}
The droid does not react. I receive the same message when I try and run the .mtn in “Motion Editor”
HELP!
Tom