I have motors like your item [font=Helvetica Neue, Helvetica, Arial, sans-serif][highlight=#fbfbfb]RB-Ban-71. The motors I have just have a round axle coming out the end. The axle is about 2 mm in diameter. How can I attach a wheel of any sort to this? If not a wheel, then a belt system would be great. Any help is appreciated.[/highlight][/font][font=Helvetica Neue, Helvetica, Arial, sans-serif][size=4][highlight=#fbfbfb][/highlight][/size][/font]
Will this fit a 2 mm axle?
Lynxmotion Aluminum Tubing Connector Hub (pair) HUB-08
robotshop.com/en/lynxmotion- … r-hub.html
The output shaft for RB-Ban-71 is 8mm in diameter, so we’re not sure how you measured it to be 2mm.
HUB-08 is meant to fit inside tubes, and the inner bore (hole) is not precision drilled.
You will likely need an 8mm hub for the CIM motor:
robotshop.com/en/mounts-hubs.html
Ex: robotshop.com/en/set-screw-h … =RB-Nex-18