hai this is the firts time I have bought a LYNX 6 and I finished assamblying and have tried to test the arm"step 2". But the arm doesn’t looks like as it is mentioned in the diagramme. it isn’t 30° up but down the horizontal. can some boby help me please.
I’m not an arm guy, so I’m not familiar with those build instructions.
However, there’s some general things to point out.
It sound like you have not properly set the servos into their limbs.
Go over the directions again, and see if you’ve oriented them improperly.
I was also facing the same problem. I found a solution for that. I changed the location of motor plate on which we have to attach arm by rotating it by desired angle. and now its ok