Hello,
I recently purchased and built an AL5D robot arm. I finished construction yesterday and wanted to plug it in to try and start programming. The first time I plugged it in, the power LED lit up and drivers were installed on my computer. Of course, I was having trouble programming and trying to figure out how to program the arm. However, I left for lunch and when I came back and plugged the board back in, my computer did not recognize the device, the power LED did not come on, and I couldn't get the arm to do anything, even flinch. Has anybody ever had this problem before? Is it fixable or did I fry my chip? Thank you for the help.
Sincerely,
mdb216