Hello, i would like to ask who can give me a version PowerPod 1.00 with H36.pmp program because i have an SSC-32 card with the old Atmel chip, i have troubles when i want to obtain a movement of my stepper motors, i wish to thank who will help me, have a good day!!
You shouldn’t need an older file to fix a problem. The latest file has the most error free code. What errors are you seeing? I’m sure we can fix your problem with a little more information.
Hello, my problem is that when i push All=1500 ms the robot try to pick up in stairs but he drop down after that and this happens for infinitely number of tries, and when i try to move my offset on every servo he don’t answer on my comands and when i push read and write he said an error about the SSC-32 on this version don’t support my Atmel v1 8 bits chip and to upgrade to Atmel V2
This is a power problem.
Do you have it configured like this? Pay close attention to the VL=VS1 jumper…
I verify the connection, when i remove that jumper from VL=VS1 the SSC-32 board is not function, when i put back that jumper the SSC-32 controller is function properly, But when i try in powerpod to enable button All=1500 ms the servos are getting that position but after that they are stopping, i mean it’s like flat body without pulses. I think this is a problem,the servos have to stay in that way i mean All=1500 ms until i press All=Off. And about the Read and write button the same response: Atmel Chipset is V1 please replace with V2 16 bits chipset, please if you can help me send to me a version H36 or H38.pmp with Atmel Chip V1 support, thanks again, have a good day!
Please wire it the way it is in the diagram above. Use a 9vdc battery for the VL! This will fix the problem. Another version of PMP file will not fix this. Please believe me I know what I’m talking about…