I have a litter robot 3 connect, took it apart to clean, i reassembeled and it seems to be stuck in the cycle mode. As soon as i press power it begins to cycle as usual, but it reaches the home position, it never lights up blue for ready, it just cyclrs again and again. Im not sure what is causing this.
It appears to know where to stop…it just never goes into ready mode. Just keeps acting as if it needs another cycle and another cycle. The light never goes from yellow to blue, just recycles after it gets done with the last cycle.
I haven’t received the cat sensor as of yet, however, I unplugged ot cleaned all around it. And it was working fine for a few days…got litter robot to reset the app, as it was attached to someone else’s account. Then I got a litter robot full alert, pulled open the app and the robot is missing from my account again. Tried to reconnect the app, and now I have a blue blinking light, when I hit reset it goes to yellow blinking.
Alright i have changed…the cat sensor…the dfi sensor…the pinch sensor, now the robot cycles gets done and all 3 lights lights flash now. What gives? Think ive replaced nearly the whole robot by now.
I reseated the hall sensors and am now back to the original problem, the robot cycles, then stops for a second and then goes back into anther cycle one after another, the blue ready light never comes on. I have switched the bonnet out, the power plug, and the globe with a second robot I have. None of these seem to make a difference. Also it appears my robot will not reconnect back to the wifi, I hold the two buttons as directed and never get a blinking light.