Introduction
Bluetooth utility vehicle is the carupgrade, the upgrade part reflect more bluetooth control part of the androidmobile phone. Bluetooth utility vehicle a microcontroller learning application developmentsystem, drive system, 4 the arduino microcontroller series Atmega-328p asthe core, the finish line, obstacle avoidance, remote control function, andsuite contains a lot of interesting program, and can expand external circuitmodule, thus increasing the use function of the car. Designed to allow users inlearning the ARDUINO microcontroller can out of boring theory knowledge, obtainthe single-chip microcomputer system development ability in the play.
The experiment course
l The application of 1. L298N motor driver board
l Tracking of intelligent vehicle
l The ultrasonic obstacle avoidance intelligent car
l Infrared remote control of intelligent vehicles
l The Arduino bluetooth remote control programmable intelligent car
l A (line 6. 4 and obstacle avoidance infrared remote bluetooth remotecontrol) program Specifications
l Size: 33 * 24 mm l Gear motor slowdown than 1:48, driving voltage 6 v.
l The control motor selection L298N drive module, and single chipmicrocomputer real isolation.
l The three groups of line module, detection of black and white line,higher precision, and fall prevention control is also available.
l Infrared remote communication module, remote control system of smartcar,
l Bluetooth wireless communication module, close the wireless remotecontrol,
l Equipped with economic environmental protection rechargeable batteryand charger, car power.
l Car length of 23 cm, 12 cm wide, can access external 7 ~ 12 vvoltage. And can carry many sensor module, according to your imagination torealize various functions.
Material List:
l Reduced Gear motor: 4 pcs
l High quality tyre: 4
l The motor fixed accessories: 4 pcs
l 100 * 213 * 5 mm organic glass plate: 1 piece
l 100 * 213 * 5 mm organic glass plate: 1 piece
l L298N motor driver board: 1pcs
l The ARDUINO UNO328 board: 1 pcs
l The ARDUINO sensor extension boards V5: 1 pcs
l Yuntai: 1 pcs l The steering gear: 1 pcs
l The ultrasonic module: 1 pcs l Three groups of line module
l The infrared receiving sensor
l Single chip microcomputer remote controller: 1pcs
l 18650 battery box: 1 pcs l 18650 charger: 1 pcs
l Bluetooth module: 1pcs
l The dupont line: 30 pcs
l 0.5 meters long USB line: 1 pcs
l The copper column 35 mm:6 pcs;20 mm 3pcs; 6 mm: 6pcs
l 3 MM screw nut several
This is a companion discussion topic for the original entry at https://community.robotshop.com/robots/show/a-rc-robot-car-by-wireless-bluetooth-based-on-arduino-board