1. Ok… didn’t know that
err… sorry to give a bad news… can’t find oscilator, 74ac04 and get 74F04 as subtitute… grounding pin 3, 5, 11, 13
the data is still zero…
1. Is it only clock that make my driver didn’t works? if it’s true, can i just take off the oscilator from wiimote board? it smd, but i guess i pull out the wire from it… can you share the pinout from it?
2. 74AC04 is cmos not gate type… and i have cd4009. its cmos to and not gate… can i use this?
3. it is silly but, is there any change i get the data from wiimote directly? from camera pin directly?
the condition is.
1. VCC from AVRprog is 5v directly from usb port
2. VCC after camera is put on the driver is 2.8v
3. using 5 v as vcc for pull-up 4k7 resistor, because i though 2.8 v not enough to pull-up
4. wii camera works fine, test by put to wiimote back again and use it in wii and dolphin emulator
5. all connection on camera is connected fine
here’s the preview
http://www.youtube.com/watch?v=Zzk1xAw6Ymc
and part
http://www.mediafire.com/download.php?a5lmq4u3quhwjpq