i recently bought a hunter 500 and a pixhawk, and im trying to set them up but i cant find the correct firmware or the ‘FRAME’ type to change. is there something im missing?
if theres anyone out there with a 500 and pixhawk running together that could talk me through it or give me a few pointer id be eternally greatful!
brilliant ill check this out tonight, being a total noob, would you be able to advise me on what parameters i would need to change/fine tune?
also what heading is that menu under? it looks different to the one i was on last night…
You will only get this menu after loading the PixHawk with APM Copter (Quadcopter for example) and have it connected (top right). It’s available in the “Initial Setup” tab.
We didn’t test this setup so we can’t recommend anything to change and/or try at this point. Sorry about that.
Just thought i would share my design for the [h1]HUNTER KILLER Aerial Drone Main Canopy[/h1]Will fit the 400 V-tail only.
This is a replacement (Center) canopy for your dialfonzo copter vtail existing canopy owners.
The HUNTER KILLER Aerial Drone Main Canopy is to be used in conjunction with its predecessors arms as now sold by Robotshop. robotshop.com/en/vtail-400- … anopy.html
Here is the FPV circuit I used for a
TBS Unify Pro 5GB HV 25-800 mW Transmitter (SMA) and a
RunCam Night Owl Camera and a RunCam2 Camera. I use the Dean Connector
for testing and Run Lights. If you want to create another Power Distribution
Board you can use this FPV Circuit.
On page 12 of the assembly guide rev 1.1, there appear to be white color (possibly aluminium) appendages on the very front and at the very rear. Those did not come with the hardware bag. Are they absolutely required?
I’m placing a Pixhawk 2.1 as the flight controller. Are there any recommendations where to place it in the frame considering the Pixhawk 2.1 does NOT use a standard 30mm x 30mm or 45mm x 45mm mounting hole pattern? I’m not sure about compatibility for VTail designs.
Internally is always best if possible, roughly centered where the main “flower” opening can be found. Check the Pixhawk software (is it genuine?) to know if a VTail design is compatible. You need to orient it correctly, and offset the weight of the battery so the center of weight of the VTail is correct. Ex: https://diydrones.com/forum/topics/pixhawk-with-v-tail-quadcopter
The canopy can help keep “internals” from flapping around, and provides a little protection, but it’s mostly aesthetic. No testing has been done to gauge the aerodynamic advantage.
Normally the package should contain the adapter - was it lost? You should contact us at [email protected] with your order number.
The shaft diameter of the MT2216 is M5, but the one in your link is M6.
Where is the MultiWii Quick Start guide referred to on page 3 of Lynxmotion Electronic Configuration? I’m looking for the flight controller installation information. I don’t see it here. http://www.lynxmotion.com/s-4-electronics-guides.aspx
I found the M5 prop adapter. So, that’s fine. I was looking for information more on how the velcro can be used and how a flight controller could be mounted correctly (more mechanical stuff). The assembly guide doesn’t have the information.